89 325i sport resto (work begins at last)

Doing a minor build / restoration or an epic one, post it here

Moderator: martauto

Post Reply
beardymat
E30 Zone Squatter
E30 Zone Squatter
Posts: 1979
Joined: Tue Jun 14, 2005 11:00 pm
Location: sheffield, city of steel, and rust apparently

Sun Feb 19, 2006 7:51 pm

well work has finally started on my sport, for those that dont know i bought my sport early last year in a damaged state for a few hundred pounds, ive always wanted one since starting as an apprentice panel beater at a bmw dealership in sheffield back in 1991.anyhow after getting involved in salvage repair last year i spotted this one in lachs silver(a personal favourite of mine) and thought id treat myself to a project

Image

Image

doesnt look much but it was unmolested and is showing 87000 miles which i have no reason to doubt.it sat on my drive for a while looking sad whilst i searched around for parts and thats how i came across the zone! :D

i found a 325ise on ebay with a blown head,air con and an obc and bought that for Ԛ£250,broke it for the bits and sold the extras off(feel a bit stupid for the things i left on which went for scrap) so then i had something which i could do to it on my drive in the sun

Image

Image

didnt take long to install the aircon heater box and obc started at 11am sunday and bolted the dash back in at around 330pm the same day.

there it sat until early this year when i finally got a workshop of my own and a jig of my own and started working for myself.lots of people commented on the car when they saw it but most said id never get it done,cue red rag to bull!!!!

so on friday i looked around and saw that none of my forthcoming jobs need the jig.good time to make a start then :wink:

Image

sat on the jig

Image

Image

Image

Image

Image

thats my better side,checking the bulkhead where the chassis leg pushes it back in an impact.

Image

using the pedal of power to pull the leg back. 10 ton pulling force can pull some pretty good chunks out of your car but the thick german metal can take it,forgotten how strong these cars are.

Image

and thats a jig on a stick for when pulling alone is not enough.

its progressed a little more but i didnt have the camera but i will post more pics when i have them.hope you enjoy the ones i do have[/img]
Last edited by beardymat on Sun May 13, 2007 8:45 pm, edited 5 times in total.
No longer self employed but still available for welding duties.
billgatese30
E30 Zone Team Member
E30 Zone Team Member
Posts: 10989
Joined: Sun Jan 09, 2005 11:00 pm
Location: Tyne & Wear

Sun Feb 19, 2006 7:56 pm

looking good matey

looks like your having fun :cool:
beardymat
E30 Zone Squatter
E30 Zone Squatter
Posts: 1979
Joined: Tue Jun 14, 2005 11:00 pm
Location: sheffield, city of steel, and rust apparently

Sun Feb 19, 2006 8:04 pm

yeah its fun alright

hoping there will be 2 tech 2s at ferrybridge this summer
No longer self employed but still available for welding duties.
billgatese30
E30 Zone Team Member
E30 Zone Team Member
Posts: 10989
Joined: Sun Jan 09, 2005 11:00 pm
Location: Tyne & Wear

Sun Feb 19, 2006 8:08 pm

i hope so, i'm sick of being the only one :P
bigkev
E30 Zone Regular
E30 Zone Regular
Posts: 612
Joined: Wed Jul 27, 2005 11:00 pm
Location: hibernating till summer

Sun Feb 19, 2006 8:20 pm

good to see somebody actually fixing an E30 and getting it back on the road instead off stripping and selling :cry:
WELL DONE :D
ad318i
E30 Zone Squatter
E30 Zone Squatter
Posts: 1574
Joined: Tue Jan 11, 2005 11:00 pm
Location: Term Time: Portsmouth Holidays: Worcester

Sun Feb 19, 2006 8:31 pm

v nice 2 see looks like you got some fun ahead of ya!!
1989 Alpine White 318i 4 Door - Got Scrapped When I Was Abroad
1993 Metallic Green 316i Touring - Im Selling it before i move back to Greece, http://cgi.ebay.co.uk/ws/eBayISAPI.dll? ... 0239342139
Demlotcrew
E30 Zone Team Member
E30 Zone Team Member
Posts: 13329
Joined: Mon Dec 20, 2004 11:00 pm
Location: East Anglia

Mon Feb 20, 2006 12:48 pm

Good work mate!

Andrew
Grantley
E30 Zone Regular
E30 Zone Regular
Posts: 486
Joined: Fri Jun 10, 2005 11:00 pm
Location: Bristol, UK

Mon Feb 20, 2006 6:43 pm

As said above, nice to see someone saving a good motor instead of letting the vultures get it. Fair play mate and good luck !
bmwe30mtech
Engaged to the E30 Zone
Engaged to the E30 Zone
Posts: 5288
Joined: Thu Feb 03, 2005 11:00 pm

Mon Feb 20, 2006 7:07 pm

Looks great, i enjoyed looking through those photoes! :) . Keep us posted, looks fun.

Paul
1988 M3 EvoII, Macau Blue/EvoII trim
1989 325i Sport M Tech II, Diamond Black/Black leather
Simon13
The longest resto in the world !
Posts: 22697
Joined: Mon Jan 10, 2005 11:00 pm
Location: Camberley, Surrey don't u know

Mon Feb 20, 2006 9:59 pm

U hero! glad u are having fun doing it.

It's good to see for once, one being saved and not broke for parts. People are breaking them for alot less too than what is wrong with this car.

Please post more pics as u go. I love the body shop photo's of repairs and the stages during a respray
bmwe30mtech
Engaged to the E30 Zone
Engaged to the E30 Zone
Posts: 5288
Joined: Thu Feb 03, 2005 11:00 pm

Mon Feb 20, 2006 10:08 pm

Simon13 wrote:I love the body shop photo's of repairs and the stages during a respray
Same 8)
1988 M3 EvoII, Macau Blue/EvoII trim
1989 325i Sport M Tech II, Diamond Black/Black leather
Nelly
Gumbo
Gumbo
Posts: 4239
Joined: Mon Jan 10, 2005 11:00 pm
Location: Divorce Central

Mon Feb 20, 2006 10:22 pm

Those Jig's kick arse, i watch on pull the front end out on a Grand Cherokee - - - - 8O the power from them is unbelievable.

Loving these progress pics as much as the VW overalls :wink: keep them coming.

Neil.
Image

"I F**KING LOVE YOU GUMBO"
beardymat
E30 Zone Squatter
E30 Zone Squatter
Posts: 1979
Joined: Tue Jun 14, 2005 11:00 pm
Location: sheffield, city of steel, and rust apparently

Mon Feb 20, 2006 11:19 pm

thanks for the positive replies guys :D

need to take the camera to work as things have moved on a bit,been to the dealers today to order two new wings,were a little steep i thought at Ԛ£100 a side but im not putting pattern panels on and spoiling the finish!

will keep you posted as things progress

p.s. cant wait till i get to the stage of ripping the heart out of my 525e daily drive for the conversion but that will be another story winkeye
No longer self employed but still available for welding duties.
Hyperion
E30 Zone Squatter
E30 Zone Squatter
Posts: 1727
Joined: Tue Jul 12, 2005 11:00 pm
Location: JHB, South Africa

Tue Feb 21, 2006 5:39 am

Nicely done mate, i wish i could do what u can. Very brave man you are. Believe me once you are done with her you can boast that u built her up ur self :wink: that 325 sport is gonna love you for saving her.
Templ8e30
E30 Zone Addict
E30 Zone Addict
Posts: 2801
Joined: Mon Jan 10, 2005 11:00 pm
Location: Ashton-under-Lyne, Lancashire

Sun Feb 26, 2006 6:06 pm

Keep up the good work Mat, it's looking better already.

Can't wait to see it finished.

I know it'll be a proper job :cool:

See you soon,

Iain T
Image
2007 Mazda 6 2.0 estate
Political Correctness - A concept based on the idea that its possible to pick up a turd by the clean end !
dazleeds
old skool raver
old skool raver
Posts: 12883
Joined: Fri Apr 01, 2005 11:00 pm
Location: Empire Building @

Sun Feb 26, 2006 6:11 pm

looking good matt

youll have to gimme a shout and i'll pop down and give ya a hand oneday
all knowledge is good and im keen to learn your skills mate :cool:

im all in turmoil at moment trying to decide if i can keep the 320i lol

as well as the rest :D
www.oldskoolfantasy.co.uk
in the shit,the one to blame,yeh its all my fault ;)
beardymat
E30 Zone Squatter
E30 Zone Squatter
Posts: 1979
Joined: Tue Jun 14, 2005 11:00 pm
Location: sheffield, city of steel, and rust apparently

Tue Feb 28, 2006 11:04 pm

got a little more done at the weekend so here are more pics

new chassis leg goes in

Image

Image

Image

the holes in the chassis leg are for the crumple zone to make it absorb some energy in an impact

Image

they certainly worked in the case of the old leg!!! made pulling the damage out harder as it would just rip from the edge of the holes,had to cut away the crumple zone in the end to get a pull off solid metal.

Image

Image

Image

managed to save the original inner wing though,all those orange lines are surface rust where the metal buckled and the paint flaked off,gives a better idea of how bad it was

Image

chassis leg finished with top section on

Image

everything coming together

Image

and with the new(genuine) wings on to check panel fit.all looks good so its time to get the welder out.it only took two working days to get the car to this stage but theres quite a bit left to do,got a few small rust spots to take care of on the rear panel and rear arches(more pics to follow) but the jacking points and sills are amazingly sound.then theres the prep for paint, not a job i enjoy much :roll:

anyway the beast is tucked away in the corner awaiting the next session which shouldnt be long coming

Image
No longer self employed but still available for welding duties.
jonbuoy
E30 Zone Addict
E30 Zone Addict
Posts: 2092
Joined: Wed May 04, 2005 11:00 pm
Location: Basildon, Essex

Tue Feb 28, 2006 11:28 pm

I really like your anisiative to rebuild such a great car, she's gonna be a beauty :wink:
Well done geese :thumb:


P.s I noticed your rev counter is stuck on the 900-1000 rpm mark, i suppose you already no that but thought i'd point it out :wink:
Image
billgatese30
E30 Zone Team Member
E30 Zone Team Member
Posts: 10989
Joined: Sun Jan 09, 2005 11:00 pm
Location: Tyne & Wear

Tue Feb 28, 2006 11:48 pm

looking good, i expect to see it at the next FB meet :cool:
User avatar
scotty86d
E30 Zone Newbie
E30 Zone Newbie
Posts: 167
Joined: Wed Nov 16, 2005 11:00 pm
Location: Uxbridge/Brighton

Tue Feb 28, 2006 11:58 pm

Looks amazing, as said before wicked to see someone is rebuilding it and not breaking it. Was fitting the air con all that difficult btw?
beardymat
E30 Zone Squatter
E30 Zone Squatter
Posts: 1979
Joined: Tue Jun 14, 2005 11:00 pm
Location: sheffield, city of steel, and rust apparently

Thu Mar 02, 2006 9:32 am

scotty86d wrote:Looks amazing, as said before wicked to see someone is rebuilding it and not breaking it. Was fitting the air con all that difficult btw?
cheers for the comments,its nice to see others appreciating my work.

the aircon is dead easy if youre good at getting the dash out,took me a sunday to swap over the heater box and rebuild the dash,after that its just pipework, wiring, pump and condensor under the bonnet.

not sure about the next ferrybridge chris,but im aiming for the summer 8)
No longer self employed but still available for welding duties.
paulj
E30 Zone Camper
E30 Zone Camper
Posts: 1101
Joined: Thu Mar 31, 2005 11:00 pm
Location: Newmarket

Thu Mar 02, 2006 9:42 am

looking good matt cant wait to see it finished :thumb:
Image
Arrogant
E30 Zone Newbie
E30 Zone Newbie
Posts: 7
Joined: Wed Mar 01, 2006 11:00 pm

Thu Mar 02, 2006 10:56 am

WOW!! 8O

That is a lovely motor!!! 8)
Geeman
Married to the E30 Zone
Married to the E30 Zone
Posts: 7641
Joined: Sun Jan 09, 2005 11:00 pm
Location: Grimsby, Lincolnshire
Contact:

Thu Mar 02, 2006 11:12 am

Matt... looks like it's coming together really well. I'm really chuffed for you.

I miss my Lachs Silver Tech 2... *sniff*

Didn't know you managed to find a 525e daily driver! Do tell us more!

Giles.
Arrogant
E30 Zone Newbie
E30 Zone Newbie
Posts: 7
Joined: Wed Mar 01, 2006 11:00 pm

Thu Mar 02, 2006 11:40 am

I'm 12, live with my mum, and only just started comprehensive school, and everyone picks on me.
dazleeds
old skool raver
old skool raver
Posts: 12883
Joined: Fri Apr 01, 2005 11:00 pm
Location: Empire Building @

Thu Mar 02, 2006 11:44 am

matt dnt suppose you can get my tec1 in there for repair in the next 3 to 4 weeks??

get in touch mate coulddo with a chat re repairs etc Daz
www.oldskoolfantasy.co.uk
in the shit,the one to blame,yeh its all my fault ;)
beardymat
E30 Zone Squatter
E30 Zone Squatter
Posts: 1979
Joined: Tue Jun 14, 2005 11:00 pm
Location: sheffield, city of steel, and rust apparently

Thu Mar 02, 2006 5:11 pm

just got home and seen my thread has got really popular but for all the wrong reasons :mad:

thanks to everyone who gave possitive responses,will keep posting pics of my scrapper as work progresses :wink:

geeman, heres a pic of my etta

Image

its got little going for it outside those wheels and a cassette holder oh and a boot spoiler too (oooohh) but it was cheap and passed a test and it doesnt have to last long.car has covered 214000 miles with dealer history to 198000 miles and the engine is still strong.paid Ԛ£237 for it :D

might be a few spares for yours when i break it :wink: will be bringing it to the next ferrybridge if this weather warms up a tad

daz, youll have to pop over to sheffield with it so we can discuss what needs doing, anytime is good with me just give us a call (pm me if you need my number)
No longer self employed but still available for welding duties.
dazleeds
old skool raver
old skool raver
Posts: 12883
Joined: Fri Apr 01, 2005 11:00 pm
Location: Empire Building @

Thu Mar 02, 2006 5:17 pm

no prob matt

will be in touch very soon

will pics of the dodgy areas do for now??
as dnt really wanna be driving the sport as no mot
obviously when work gets done i will have to but dnt wanna risk too often lol

cars coming on well mate glad youve got into it now :cool:
www.oldskoolfantasy.co.uk
in the shit,the one to blame,yeh its all my fault ;)
beardymat
E30 Zone Squatter
E30 Zone Squatter
Posts: 1979
Joined: Tue Jun 14, 2005 11:00 pm
Location: sheffield, city of steel, and rust apparently

Thu Mar 02, 2006 5:22 pm

ill have to pop over to yours daz, could do with a proper poke around to see whats what. maybe this weekend so keep that kettle boiling.

might come in the gold heap too if youre lucky :D
No longer self employed but still available for welding duties.
dazleeds
old skool raver
old skool raver
Posts: 12883
Joined: Fri Apr 01, 2005 11:00 pm
Location: Empire Building @

Thu Mar 02, 2006 5:26 pm

:cool: matt

i'll b here

if ya cant make it and i have to drive it over then i will but will pik a busy time to blend in as much as poss lol

as car is far from subtle at the moment lol
and with blowing exhaust etc it makes itself heard shall we say lol

could do with someone here as jacking it up alone aint easy either
and cnt see mrs lifting car for me somehow lol

will pull skirts etc off asap incase ya do come cheers matt

ps dnt forget my offer to help with yours

still stands mate

Daz

ps kettles on 24hour shifts here :D
www.oldskoolfantasy.co.uk
in the shit,the one to blame,yeh its all my fault ;)
Simon
E30 Zone Team Member
E30 Zone Team Member
Posts: 14939
Joined: Sun Jan 09, 2005 11:00 pm
Location: South Wales
Contact:

Thu Mar 02, 2006 7:34 pm

Matt, just read your post, great post, shame it's been ruined by one idiot.

Do you want me to tidy it up for you?
Image
beardymat
E30 Zone Squatter
E30 Zone Squatter
Posts: 1979
Joined: Tue Jun 14, 2005 11:00 pm
Location: sheffield, city of steel, and rust apparently

Thu Mar 02, 2006 8:19 pm

thanks for the compliment, i can rise above the stupid remarks but if you could tidy it up that would be great
No longer self employed but still available for welding duties.
Simon
E30 Zone Team Member
E30 Zone Team Member
Posts: 14939
Joined: Sun Jan 09, 2005 11:00 pm
Location: South Wales
Contact:

Thu Mar 02, 2006 8:34 pm

Consider it done :D

Note, I've left some of his posts there...wonder how long before someone notices them :twisted:
Image
Weezie
Xbox widow
Posts: 1127
Joined: Tue Nov 08, 2005 11:00 pm
Location: Ware, Herts

Thu Mar 02, 2006 8:39 pm

Simon wrote:Consider it done :D

Note, I've left some of his posts there...wonder how long before someone notices them :twisted:

:lol: :lol: :lol: Well done!
dazleeds
old skool raver
old skool raver
Posts: 12883
Joined: Fri Apr 01, 2005 11:00 pm
Location: Empire Building @

Thu Mar 02, 2006 8:48 pm

Simon wrote:Consider it done :D

Note, I've left some of his posts there...wonder how long before someone notices them :twisted:
:thumb: now thats spring cleaning :snigger:
www.oldskoolfantasy.co.uk
in the shit,the one to blame,yeh its all my fault ;)
Post Reply