E30 Zone

yesterday i was driving along in the 320is and the guage stopped working.when i would rev up thru the gears it would go mental up down up down when i would slow down it stoppped. any one got any info. i did a search but couldnt come across any thing similar?

any one??

one of the senders are faulty pop up the back seat, remove the inspection plate n unplug one at a time see when it stops being erratic. then you'll figure which ones buggered

also worth removing the cluster and checking the small 8mm nut behind the fuel guage. to remove guage click links, technical then find the dash swap site it explains how to remove cluster.

easy way to see if it is this part is to whack the top of the dash when it goes funny, if it returns to normal try my tip, if not try the above

mrlee

i had the same problem and went for the "nut on the back" attack which worked, mind you the nut was missing so i nicked the one from the temp gauge , all is fine and dandy now

cheers for the advice and tips always good to get input. i tried the sender in the pump will go a clocks now

update i took out the cluster and the nut is not lose. is there two sender units one under both sides of the rear seat. at my witts end now with this. would it be the si batteries?

yes that is correct there is two senders. the one that was shot on mine was... n/s/r! good luck hope you get to the bottom of it all!

only checked the sender under the driver side aka right hand. i didnt realise there was a second. the guage goes to three quater and fluctuates from there up and down

paddyvw wrote:update i took out the cluster and the nut is not lose. is there two sender units one under both sides of the rear seat. at my witts end now with this. would it be the si batteries?

Did you try to nip it up a bit more anyway? Mine didn't appear to be loose, but was flickering about. I nipped it up a tiny bit (didn't even really seem to tighten it was that little amount) and touch wood, it hasn't given me any more problems. That was 4 or so months ago now.



Regards,

Ian

ya tightened it a bit but it wa tight. i definatly went as a far as i am happy with out breaking some thing it is that tight

Yeah, I have had this problem in the past. It was my fuel sender sensor under the rear seats. So take the old one out and clean it, it may work or just replace it, its a small cheap fix. Do that and it should be fine.

thanks don plan of action for tomorrow. on way home this eve battery died so recon the regulater is gone so another job to be done. but man i lve the buzz when they working 100%

update is i got it fixed finally this eve. i took out the sender under the back seat opened it up to see the floataion wire was broke. we went to the spare parts department(scrap e30s) and got one out of a 316 touring. interestingly was that a 325 sport dont have the second sender or a 316 saloon but the touring does. any way fixed now and rocking around!!